伸縮棚的施工方法及工藝流程

　　Construction method and process flow of retractable shed

　　伸縮棚的施工方法及工藝流程可分為以下五個核心步驟，結合權威信息整理如下：

　　The construction method and process flow of the retractable shed can be divided into the following five core steps, which are summarized based on authoritative information as follows:

　　一、施工前準備

　　1、 Preparation before construction

　　選址與設計

　　Site selection and design

　　確定安裝位置，測量遮擋范圍，根據防風等級、負載需求選擇型號（如果園避雨棚需抗風≥8級、雪載≥0.3kN/㎡）。

　　Determine the installation location, measure the coverage range, and select the model based on the wind resistance level and load requirements (if the garden rain shelter needs to withstand wind resistance ≥ 8 levels and snow load ≥ 0.3kN/㎡).

　　材料與工具準備

　　Preparation of materials and tools

　　選擇耐腐蝕、輕便的材料（如熱鍍鋅鋼管、鋁合金），準備膨脹螺栓、水平儀等工具。

　　Choose corrosion-resistant and lightweight materials (such as hot-dip galvanized steel pipes, aluminum alloys), and prepare tools such as expansion bolts and level gauges.

　　二、基礎工程

　　2、 Basic Engineering

　　地基處理

　　ground improvement

　　按獨立柱基礎+地梁設計，澆筑C30混凝土基礎，預埋M30地腳螺栓，確保柱間距≤4m且基礎頂面高于地面10cm防積水。

　　According to the design of independent column foundation and ground beam, pour C30 concrete foundation, embed M30 anchor bolts, ensure that the column spacing is ≤ 4m and the top surface of the foundation is 10cm above the ground to prevent water accumulation.

　　支架安裝

　　bracket installation

　　立柱垂直度校正（誤差≤3mm/m）；

　　Column verticality correction (error ≤ 3mm/m);

　　拱架吊裝并緊固螺栓（扭矩≥220N·m）；

　　Arch lifting and tightening bolts (torque ≥ 220N · m);

　　導軌安裝水平度校準（±5mm/10m）。

　　Horizontal calibration of guide rail installation (± 5mm/10m).

　　三、骨架結構搭建

　　3、 Skeleton structure construction

　　主體框架

　　main framework

　　采用熱鍍鋅鋼管或鋁合金搭建拱形桁架，縱向?qū)к壟c支架連接，確保結構穩定性。

　　Use hot-dip galvanized steel pipes or aluminum alloys to construct arched trusses, with longitudinal guide rails connected to brackets to ensure structural stability.

　　伸縮機構安裝

　　Installation of telescopic mechanism

　　安裝電動/手動開關控制的伸縮臂，需預測試延伸長度并固定。

　　Install the telescopic arm controlled by electric/manual switch, and pre test the extension length and fix it.

　　四、覆蓋系統安裝

　　4、 Covering system installation

　　材料選擇

　　Material selection

　　頂部采用PO膜（透光率92%、壽命5年）或防蟲網（40目）；

　　The top is made of PO film (with a light transmittance of 92% and a lifespan of 5 years) or insect proof mesh (40 mesh);

　　填充材料根據需求選擇保溫/隔音材料。

　　Choose insulation/sound insulation materials according to the requirements for filling materials.

　　組件固定

　　Component fixation

　　固定件通過膨脹螺栓安裝于立柱，確保伸縮臂與支架連接牢固；

　　The fixed components are installed on the column through expansion bolts to ensure a secure connection between the telescopic arm and the bracket;

　　遮陽布預處理后懸掛于伸縮臂，調整水平或適當高度。

　　After pre-treatment, hang the sunshade cloth on the telescopic arm and adjust it to a horizontal or appropriate height.

　　五、驗收與維護

　　5、 Acceptance and maintenance

　　檢查

　　comprehensive inspection

　　檢查支架、伸縮臂、覆蓋材料固定情況，確保無松動或變形；

　　Check the fixing condition of the bracket, telescopic arm, and covering material to ensure that there is no looseness or deformation;

　　測試防雨/防雹功能（如果園棚需通過模擬測試）。

　　Test the rain/hail prevention function (if the shed needs to pass simulation testing).

　　后期維護

　　post-maintenance

　　定期清潔遮陽布，避免懸掛重物，及時維修機械故障。

　　Regularly clean the sunshade cloth, avoid hanging heavy objects, and promptly repair mechanical failures.

　　注意事項 ：若涉及復雜結構（如全自動避雨棚），建議聘請人員施工。

　　Attention: If complex structures are involved (such as fully automatic rain shelters), it is recommended to hire professional personnel for construction.

　　伸縮棚的維護周期主要取決于使用頻率和維護方式，具體如下：

　　The maintenance cycle of the retractable shed mainly depends on the frequency of use and maintenance method, as follows:

　　基礎維護周期

　　Basic maintenance cycle

　　日常維護 ：若全年使用，建議每6個月對伸縮棚進行防銹漆涂刷，以保護金屬支架免受氧化。

　　Daily maintenance: If used throughout the year, it is recommended to apply anti rust paint to the retractable shed every 6 months to protect the metal brackets from oxidation.

　　活動部件保養 ：需定期涂抹油脂或黃油，確?；顒?dòng)關節順暢。

　　Maintenance of moving parts: Regular application of grease or butter is required to ensure smooth movement of the joints.

　　維護有效期

　　Maintain validity period

　　在正確使用和定期維護的前提下，伸縮棚可維持5-7年使用壽命。若維護不當，實際壽命可能縮短。

　　Under proper use and regular maintenance, the retractable shed can maintain a service life of 5-7 years. If not maintained properly, the actual lifespan may be shortened.

　　特殊環境維護

　　Special environment maintenance

　　風力較大時，需將伸縮棚卷起固定，避免支架變形。

　　When the wind is strong, the retractable shed needs to be rolled up and fixed to avoid deformation of the support.

　　總結 ：常規使用下，伸縮棚維護周期為半年一次（防銹漆）+ 活動部件定期保養，總有效期約5-7年。

　　Summary: Under normal use, the maintenance cycle of the retractable shed is once every six months (with anti rust paint)+regular maintenance of the moving parts, with a total effective period of about 5-7 years.

　　本文由  濟南伸縮棚   友情奉獻.更多有關的知識請點擊  http://m.jyxingyu.com/   真誠的態度.為您提供為的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is a friendly contribution from Jinan retractable shed For more related knowledge, please click http://m.jyxingyu.com/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.